[an error occurred while processing this directive]
 
       首 页  |  期刊介绍  |  编委会  |  投稿指南  |  期刊订阅  |  广告合作  |  留言板  |  联系我们 |  English
现代隧道技术 2022, Vol. 59 Issue (6) :258-265    DOI:
新型材料与设备 最新目录 | 下期目录 | 过刊浏览 | 高级检索 << [an error occurred while processing this directive] | [an error occurred while processing this directive] >>
粗合成纤维在排水调蓄盾构法隧洞管片中的应用试验研究
(1.上海市政工程设计研究总院(集团)有限公司,上海 200092;2.上海城投水务集团有限公司,上海 200002;3.上海隧道工程有限公司,上海 200032)
Test and Study on the Application of Synthetic Macro-fibers in the Segements of Drainage and Storage Tunnels Built by Shield Method
(1. Shanghai Municipal Engineering Design Institute (Group) Co., Ltd., Shanghai 200092; 2. Shanghai Chengtou Water Group Co., Ltd.,Shanghai 200002; 3. Shanghai Tunnel Engineering Co., Ltd., Shanghai 200032)
Download: PDF (4058KB)   HTML (1KB)   Export: BibTeX or EndNote (RIS)      Supporting Info
摘要 为缓解排水调蓄盾构法隧洞内水压的不利作用,考虑隧洞内部介质为雨污水,提出在隧洞管片中加入粗合成纤维。通过材料力学性能试验、直梁加载试验,研究粗合成纤维在排水调蓄隧洞管片中的应用效果。结果表明,与素混凝土力学参数相比,纤维混凝土的抗压强度、抗折强度、弹性模量分别降低1.8%、7%、4%,纤维的添加会降低混凝土力学性能;在混凝土开裂后,PPF1(粗合成纤维1)、PPF2(粗合成纤维2)、SF(钢纤维)试件的钢筋应力与普通混凝土相比分别下降2%、10%、17%,纤维分担了钢筋的部分拉应力,体现了纤维混凝土的优点;从裂缝的分布形态看,普通钢筋混凝土的裂缝表现为“疏而宽”,试验终止时最大裂缝宽度为0.55 mm,纤维钢筋混凝土的裂缝表现为“密而窄”,试验终止时最大裂缝宽度为0.3 mm。在混凝土开裂后,纤维减小了裂缝的宽度,纤维的加入有利于隧洞衬砌结构的裂缝控制。
Service
把本文推荐给朋友
加入我的书架
加入引用管理器
Email Alert
RSS
作者相关文章
官林星 1 温竹茵 1 王晓鹏 2 由广明 1 孙 巍 1 庄欠伟 3
关键词盾构隧道   管片   纤维混凝土   裂缝     
Abstract: In order to alleviate the adverse effect of water pressure in the drainage and storage shield tunnel, it is proposed to add synthetic macro-fiber into the tunnel segment considering that the internal medium of the tunnel is rainwater and sewage. Through material mechanical properties and straight beam loading tests, the application effect of synthetic macro-fiber in drainage and storage tunnel segments is studied. The results show that, compared with the mechanical parameters of plain concrete, the compressive strength, flexural strength and elastic modulus of fiber reinforced concrete are reduced by 1.8%, 7% and 4% respectively, and the addition of fiber will reduce the mechanical properties of concrete. After the concrete cracks, the reinforcement stress of PPF1 (synthetic macro-fiber 1),PPF2 (synthetic macro-fiber 2) and SF (steel fiber) specimens decreases by 2%, 10% and 17% respectively compared with that of ordinary concrete. The fiber shares part of the tensile stress of the reinforcement, reflecting the advantages of fiber reinforced concrete. From the distribution pattern, the cracks of ordinary reinforced concrete are"sparse and wide", and the maximum crack width at the end of the test is 0.55 mm; the cracks of synthetic fiber reinforced concrete are "dense and narrow", and the maximum crack width at the end of the test is 0.3 mm. After the concrete cracks, the fiber reduces the width of the crack, and the addition of fiber is beneficial to the crack control of the tunnel lining structure.
KeywordsShield tunnel,   Segment,   Fiber reinforced concrete,   Crack     
基金资助:上海市科学技术委员会优秀技术带头人计划项目(19XD1432800).
作者简介: 官林星(1978-),男,博士,正高级工程师,主要从事隧道工程的设计与研发工作,E-mail: guanlinxing@smedi.com.
引用本文:   
官林星 1 温竹茵 1 王晓鹏 2 由广明 1 孙 巍 1 庄欠伟 3 .粗合成纤维在排水调蓄盾构法隧洞管片中的应用试验研究[J]  现代隧道技术, 2022,V59(6): 258-265
GUAN Linxing1 WEN Zhuyin1 WANG Xiaopeng2 YOU Guangming1 SUN Wei1 ZHUANG Qianwei3 .Test and Study on the Application of Synthetic Macro-fibers in the Segements of Drainage and Storage Tunnels Built by Shield Method[J]  MODERN TUNNELLING TECHNOLOGY, 2022,V59(6): 258-265
链接本文:  
http://www.xdsdjs.com/CN/      或     http://www.xdsdjs.com/CN/Y2022/V59/I6/258
 
没有本文参考文献
[1] 陈莹莹 1,2 刘新根 1,2 黄永亮 3,4 李明东 1.基于神经网络与边缘修正的隧道衬砌裂缝识别[J]. 现代隧道技术, 2022,59(6): 24-34
[2] 王子健 1 刘 腾 2 冀晓东 1 刘学彦 1.斜坡条件下盾构隧道开挖面稳定极限上限研究[J]. 现代隧道技术, 2022,59(6): 42-50
[3] 袁向华 1,2 朱雁飞 1 朱叶艇 1,2.基于最大压力冗余原则的盾构推拼同步技术试验验证[J]. 现代隧道技术, 2022,59(6): 106-113
[4] 陈仁东 1 陆 平 2 孙 烨 1 刘明高 1 庞 康 1.超大直径盾构隧道横通道离心模型试验研究[J]. 现代隧道技术, 2022,59(6): 114-124
[5] 周胜利.软弱泥岩大直径盾构姿态失稳与处理措施研究[J]. 现代隧道技术, 2022,59(6): 208-215
[6] 刘 彬 1 赵东平 2,3 李 栋 3.复合地层盾构隧道下穿高速公路洞内注浆加固范围研究[J]. 现代隧道技术, 2022,59(6): 187-196
[7] 曹 妍 1 王芮文 1,2 赵蔚蔚 2 史奇彬 3 潘旭辉 3 欧定福 1,2.隧道二次衬砌混凝土仿生自愈技术应用研究[J]. 现代隧道技术, 2022,59(6): 250-257
[8] 黄忠凯 1 张冬梅 1 周文鼎 1 程屹歆 1 仝 跃 2.基于贝叶斯网络的盾构隧道横截面变形预测方法[J]. 现代隧道技术, 2022,59(5): 10-17
[9] 杨振华.浅覆土接收盾构隧道环间压力分布规律研究[J]. 现代隧道技术, 2022,59(5): 18-26
[10] 赵森森 张冬梅 黄忠凯.大直径盾构隧道分布式凹凸榫受力特性[J]. 现代隧道技术, 2022,59(5): 54-62
[11] 李春林 1 张西文 2,3 刘广森 2,3 刘俊岩 2,3 刘 燕 2,3 孙文昊 4 张亮亮 4 何应道 4.循环荷载作用下大直径盾构隧道力学变形特性研究[J]. 现代隧道技术, 2022,59(5): 47-53
[12] 崔庆龙 1 李 金 1 高斌勇 2 熊欣悦 2.大直径盾构隧道管片纵缝三斜螺栓接头力学特性研究[J]. 现代隧道技术, 2022,59(5): 63-71
[13] 李翔宇 1,2 李新源 3 李明宇 4 杨 潇 5 黄 沛 6.不同程度渗漏水对盾构隧道长期沉降影响规律研究[J]. 现代隧道技术, 2022,59(5): 72-79
[14] 莫伟樑 1 杨雨冰 1 林越翔 2,3 卢明健 1.基于OFDR技术的盾构隧道管片错台变形测量与计算方法[J]. 现代隧道技术, 2022,59(5): 179-187
[15] 章庭瑞.大型盾构隧道火灾高温特性及力学行为研究[J]. 现代隧道技术, 2022,59(5): 202-211
Copyright 2010 by 现代隧道技术