[an error occurred while processing this directive]
 
       首 页  |  期刊介绍  |  编委会  |  投稿指南  |  期刊订阅  |  广告合作  |  留言板  |  联系我们 |  English
现代隧道技术 2021, Vol. 58 Issue (6) :251-256    DOI:
施工技术 最新目录 | 下期目录 | 过刊浏览 | 高级检索 << [an error occurred while processing this directive] | [an error occurred while processing this directive] >>
利用废弃红砂岩制备盾构同步注浆材料研究
(1 西宁市轨道交通有限责任公司,西宁 810001;2 兰州市轨道交通有限公司,兰州 730070)
Study on Preparation of Synchronous Grouting Material from Excavated Red Sandstone in Shield Tunnelling
(1 Xining Rail Transit Co., Ltd., Xining 810001; 2. Lanzhou Rail Transit Co., Ltd., Lanzhou 730070)
Download: PDF (1231KB)   HTML (1KB)   Export: BibTeX or EndNote (RIS)      Supporting Info
摘要  兰州地铁盾构隧道穿越大面积红砂岩地层,红砂岩富含水,弱胶结,级配良好,含泥量约为5%。盾构开挖后直接将弃渣外运,不仅会造成资源浪费,还会引起相关环境问题。为此,文章开展了将盾构掘进同步注浆材料河砂替换为红砂岩的可行性研究。结果表明,采用红砂岩配置的同步注浆浆液满足所有技术指标,且节省成本约40%;浆液的流动性更好,堵管率降低了约70%。可通过调整膨润土的添加量来控制浆液含泥量的大小。还可利用红砂岩制成透水石应用到市政道路等工程中。这不仅解决了工程建设中原材料供应紧张的问题,同时也缓解了挖掘山体和河道采砂采石造成的环境破坏问题。
Service
把本文推荐给朋友
加入我的书架
加入引用管理器
Email Alert
RSS
作者相关文章
郭贵斌 1 靳世鹤 2 刘 奇 2 孙红斌 2
关键词:   
Abstract: The shield-driven tunnels of Lanzhou Metro pass through a large area of red sandstone stratum with rich water, low cementation, good grading and the mud content of about 5%. Direct mucking after shield excavation might not only waste resources, but also cause relevant environmental problems. So, in this paper, a feasibility study is carried out for replacing river sands of synchronous grouting materials with red sandstone from shield tunnelling.The results show that the synchronous grouting mortar prepared with red sandstone can meet all technical indexes,with saving cost by about 40%, achieving better fluidity and reducing plugging rate by about 70%. The mud content of grout can be controlled by adjusting the addition amount of bentonite. Moreover, the permeable stone can also be made of red sandstone and used for municipal roads and other projects. It might not only solve the tight supply of raw materials in engineering construction, but also alleviate environmental damage caused by sand and stone mining in mountains and rivers.
KeywordsLanzhou metro,   Shield tunnel,   Red sandstone,   Recycling,   Synchronous grouting     
基金资助:基金项目:国家自然科学基金(41562013).
作者简介: 作者简介:郭贵斌(1987-),男,硕士,高级工程师,主要从事岩土与地下工程规划、设计与施工技术方面的研究工作,E-mail:569539306@qq.com.
引用本文:   
郭贵斌 1 靳世鹤 2 刘 奇 2 孙红斌 2 .利用废弃红砂岩制备盾构同步注浆材料研究[J]  现代隧道技术, 2021,V58(6): 251-256
GUO Guibin1 JIN Shihe2 LIU Qi2 SUN Hongbin2 .Study on Preparation of Synchronous Grouting Material from Excavated Red Sandstone in Shield Tunnelling[J]  MODERN TUNNELLING TECHNOLOGY, 2021,V58(6): 251-256
链接本文:  
http://www.xdsdjs.com/CN/      或     http://www.xdsdjs.com/CN/Y2021/V58/I6/251
 
没有本文参考文献
[1] 冯冀蒙 1,2 蒋 辉 1,2 丁晓琦 1,2 虞龙平 1,2 张俊儒 1,2.并行双洞隧道穿越滑坡工程研究进展与挑战[J]. 现代隧道技术, 2021,58(6): 1-10
[2] 卢冠楠 1 王 鹏 1 杨 蕴 2 毛成君 3 吴咏敬 4 吴剑锋 3 董 平 3, 4 吴吉春 3.岩溶区隧道排水系统地下水渗流结晶堵塞机理及阻垢技术研究综述[J]. 现代隧道技术, 2021,58(6): 11-20
[3] 董建松.厦门海沧海底隧道穿越风化槽施工技术[J]. 现代隧道技术, 2021,58(6): 197-203
[4] 付 雷 马 鑫 邵 炜.冷水混入模式对藏南隧道高温热害预测的影响[J]. 现代隧道技术, 2021,58(6): 21-30
[5] 花晓鸣 罗晨曦 苟晓军 张海超.结合Landsat 8遥感影像的长大深埋隧道地表地热空间分布特征分析——以高黎贡山隧道为例[J]. 现代隧道技术, 2021,58(6): 31-37
[6] 王明年 1,2 崔 鹏 1,2 于 丽 1,2 卢旭东 3 胡萧越 1,2 夏鹏曦 1,2.基于台阶试验的相对最大摄氧量与人员疏散能力关系研究[J]. 现代隧道技术, 2021,58(6): 38-45
[7] 周晓军 1 郭 建 1 杨昌宇 2 卿伟宸 2 熊国兴 2 旷文涛 2 潘英东 1.钻爆法双线铁路隧道预制拼装二次衬砌分块方式研究[J]. 现代隧道技术, 2021,58(6): 46-58
[8] 何乐平 1 徐应东 1 胡启军 1 蔡其杰 2.基于博弈论-云模型的软岩隧道大变形风险评估[J]. 现代隧道技术, 2021,58(6): 85-94
[9] 郝俊锁.复杂地质特长深埋水工隧洞智能化施工关键技术研究[J]. 现代隧道技术, 2021,58(6): 188-196
[10] 魏 纲 1 郝 威 2 魏新江 1 王 霄 2 章书远 2.竖向顶管施工全过程数值模拟研究[J]. 现代隧道技术, 2021,58(6): 59-67
[11] 肖尊群 1,2,3 曹童童 1 许彩云 1 杨 凯 2 董琼英 1 姜亦男 1 耿星月 1 舒志鹏 1.基于叠加原理的大尺寸矩形截面竖向曲线顶管顶进力数值估算方法[J]. 现代隧道技术, 2021,58(6): 68-76
[12] 徐公允 1 徐汪豪 1,2 姚志刚 1 方 勇 1 刘四进 3.基于三维RBD-DEM耦合方法的贯入角度对滚刀冲击影响分析[J]. 现代隧道技术, 2021,58(6): 77-84
[13] 来弘鹏 1 王 斌 1 刘禹阳 2.考虑地层开裂的浅埋黄土隧道围岩压力计算方法[J]. 现代隧道技术, 2021,58(6): 95-101
[14] 张冬梅 1,2 陈淙岑 2.管片钢筋和螺栓锈蚀条件下盾构隧道结构时变可靠度分析[J]. 现代隧道技术, 2021,58(6): 111-120
[15] 黄迪文 霍宏斌 陈 东.基于优化神经网络的圆形隧道受剪变形分析[J]. 现代隧道技术, 2021,58(6): 102-110
Copyright 2010 by 现代隧道技术